Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB160  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  CULVER'S OF BOURBONNAIS Address  983 N CONVENT ST
Owner or Operator   MAIER, BOBBY City   BOURBONNAIS Zip Code   60914
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
X
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
  
1
 Wiping cloths: clean, use restricted
22
  
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
  
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
X
1
 Thermometers provided and conspicuous
37
  
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
X
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
  
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
X
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
X
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
X
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
  
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes     No     Registered for class X
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
X
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   Quat 200-400 ppm                   Dishwasher Temperature   120-140 °F or label
Food Temperatures:   BBQ Pork 117, chili 160, chicken gravy 145, brown gravy 145, blue cheese 38, raw hamburger 41, corn beef 35, pork 181, beef gravy 153, turkey noodle 165, cream of brocolli 183
 
General Comments
 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  01/23/2009 Time In  2:00 PM Time Out  3:15 PM Sanitation Score  82 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  92  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB160  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  CULVER'S OF BOURBONNAIS Address  983 N CONVENT ST
Owner or Operator   MAIER, BOBBY City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*3  OBSERVED THE FOLLOWING HOT POTENTIALLY HAZARDOUS FOODS TO NOT BE HELD AT THE PROPER INTERNAL TEMPERATURE. BBQ PORK WAS FOUND AT 117F. THE MANAGER REHEATED IT TO 165F. THE INTERNAL TEMPERATURE OF POTENTIALLY HAZARDOUS FOODS SHALL BE 135°F, OR ABOVE EXCEPT DURING NECESSARY PERIODS OF PREPARATION, INCLUDING FOODS REQUIRING TRANSPORTATION.750.120 IMMEDIATE/ONSITE
*41  OBSERVED THE FOLLOWING TOXIC CHEMICAL CONTAINER(S) TO NOT BE PROPERLY LABELED: THERE IS NO LABEL FOR THE SANITIZER ABOVE THE MOP SINK. PROVIDE FOR ALL CHEMICAL CONTAINERS THAT NO LONGER HAVE THE ORIGINAL LABEL ON THEM TO BE LABELED WITH CHEMICAL CONTENT. 750.820 IMMEDIATE/ONSITE
5  OBSERVED NO THERMOMETER TO BE AVAILABLE IN THE FOLLOWING UNITS. THERE IS NO THERMOMETER IN THE CUSTARD FREEZER. PROVIDE FOR AN ACCURATE, CONSPICUOUS THERMOMETER, THAT IS ACCURATE WITHIN +/- 3°F, TO BE AVAILABLE IN ALL UNITS HOLDING POTENTIALLY HAZARDOUS FOODS. 750.140 NEXT INSPECTION
9  OBSERVED FOOD SERVICE EMPLOYEES TO BE HANDLING READY-TO-EAT FOODS WITHOUT MINIMIZING DIRECT HAND CONTACT WITH THE FOOD PRODUCT. CUPS WERE USED FOR NUTS. USE FOOD SCOOPES WITH HANDLES ONLY. FOOD EMPLOYEES SHALL AVOID DIRECT CONTACT WITH READY-TO-EAT FOOD WHENEVER POSSIBLE AND, TO THE EXTENT POSSIBLE, SHALL HANDLE READY-TO-EAT FOOD ONLY WITH SUITABLE UTENSILS SUCH AS A DELI TISSUE, SPATULAS, TONGS, OR SINGLE-USE GLOVES. 750.280 NEXT INSPECTION
10  OBSERVED THE FOLLOWING UTENSIL(S) TO BE IMPROPERLY STORED. FOOD SCOOP HANDLE WAS FOUND IN FISH BATTER IN THE DRY STORAGE AREA. PROVIDE FOR ALL UTENSILS TO BE STORED IN ONE OF THE FOLLOWING MANNERS: 1) CLEAN AND DRY 2) IN THE FOOD PRODUCT WITH THE HANDLE UP AND OUT OF THE FOOD PRODUCT 3) IN A DIPPER WELL, USING POTABLE WATER 4) MALT COLLARS AND FROZEN DESSERT UTENSILS EITHER CLEAN AND DRY OR INA DIPPER WELL. 750.280 NEXT INSPECTION
23  OBSERVED THE FOLLOWING CONTACT SURFACES TO BE UNCLEAN. 1. SEAL GASKETS HAVE FOOD DEBRIS IN THEM. CLEAN AND MAINTAIN. 750.800 NEXT INSPECTION
25  OBSERVED THE FOLLOWING SINGLE SERVICE ARTICLES TO BE IMPROPERLY STORED: LIDS FOR CUPS WERE FOUND ON THE FLOOR IN MAINTENANCE ROOM. PROVIDE FOR ALL SINGLE SERVICE ARTICLES TO BE STORED AT LEAST SIX INCHES OFF OF THE FLOOR IN CLOSED COVERED CONTAINERS WHICH PROTECT THEM FROM CONTAMINATION. 750.880 NEXT INSPECTION
33  OBSERVED DUMPSTER LIDS WERE LEFT OPEN AND NEED TO BE KEPT SHUT. 750.1150 NEXT INSPECTION
     
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  01/23/2009 Time In  2:00 PM Time Out  3:15 PM Sanitation Score  82 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  92  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB160  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  CULVER'S OF BOURBONNAIS Address  983 N CONVENT ST
Owner or Operator   MAIER, BOBBY City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  01/23/2009 Time In  2:00 PM Time Out  3:15 PM Sanitation Score  82 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  92